so over the past few days I've put my creation thru its paces... but im running into overheating issues, even at start up.
at cold start, the guage will keep climbing past the half way point and the electric fans turn on as well.
Living in canada is **** ing cold so I dont see what is going on.

I take the freeway to work and only stop at 2 traffic lights, 22-25 minutes to work. by the time i get there driving at a granny pace (NO BOOST) the guage has peaked just under the top of the guage.

Oil, Coolant level is normal and the thermostat is brand new after i stomped on the original 5s-fe one. No leaks!

When i got this engine running as a 5s-ge is never had this problem (I put 600kms on it in One day@ regular operating temp) and remember, I rarely boost it going to work now thats its turbo'd.

Advice? quesiton me if u need more info regarding this situation.

This post has been edited by Mstoochn: Nov 5, 2009 - 5:25 PM

headgasket leak? you could be blowing exhaust into your cooling system.

smoke?
heater works?
try with heater full on

broken thermostat maybe, check to see if its opening or not. Also could be exhaust back pressure, check to see if the intake vacuum is sufficient, if not that's your culprit right there.

This post has been edited by freddy121389: Nov 6, 2009 - 1:52 AM

freddy, what backpressure ? i order a new thermostat from toyota, will see monday.
celicajoe, i current dont have a working climate control panel as i beat the sh*t out of it to pull out my stock 5s ecu, i also destroyed my stock radio to make room for EMS components easy access. I love usb ports. there so handy
bitter, unless a compression test wont show a small leak into the coolant passages i can rule that out, still sitting at 210/205/205/205

This post has been edited by Mstoochn: Nov 6, 2009 - 2:34 AM

cant rule it out, Im currently rebuilding my 3sgte again, hot exhaust gas is leaking into the coolant system. already did a HG, might be a cracked block or warped block. either way im building a sleeved stroker 5sgte.
hope you find your problem out. take your car to a garage and have the coolant checked for exhaust gases.

really? are you guys not seeing what is wrong?? not the thermostat... its the temperature sensor... the fans operate off of it, as well as the gauge.... its reading the wrong temp... replace the sensor

or reconfigure your EMS

This post has been edited by pittfirefighter: Nov 6, 2009 - 3:21 AM

>

*facepalm*

>
wtf??when driving down the road the fans arent doing anything..the fans dont kick on unless its really hott or on idle...Tooch,check ur thermastat(make sure its not backwards),doubt its HG..So the 5sge was fine?but the 5sgte is overheating??What did u change when u turboed??

>

thats the thing andrew, i didn't change anything, like i said. im not even boosting it and its doing it. I had almost 1000kms/12-15 hours on the engine and it ran JUST FINE. now its doing this

yes, the fans act as moving air when you aren't moving. In otherwords, they simulate air flow thru the rad which you only get while moving. but when the engine is cold there is no reason for them to come on

This post has been edited by Mstoochn: Nov 6, 2009 - 2:11 PM

you can't base throwing a turbo on it to be the reason its over heating, it probably would have happened eventually and just happened to happen when you turbo'd the car, just a conscience,

>

i stated i wasn't boosting it, meaning the turbo has no effect on what is going on..... the issue just suddenly happened

didnt see that part sorry

>

looks like the temp sensor on the head is bad, figures it came from the FE head so of course its no good Lol.

This post has been edited by Mstoochn: Nov 7, 2009 - 1:13 AM

bam... nailed it

>

actualy bmj did thnx paul via msn!

glad it was something that simple dude!